皇菠萝服务热线:

0531-66729399

黄菠萝动态

联系我们

  • 电话:0531-66729399
  • 15853137666
  • 邮编:250000
  • 邮箱:polo-king@163.com
  • 公司地址:济南工业北路通运汽配城2排18
位置:首页>>黄菠萝动态

黄菠萝动态

如何在济南快速钣金喷漆时避免漆面污染

时间:2015-07-10 01:44:47 来源:本站 已浏览: 392次

汽车作为我们的代步工具,我们都喜欢把它打扮的漂漂亮亮的,这样开出去倍有面子。汽车部件喷涂就能满足您的要求,只要您想的到的,喷漆厂家就能为您做到。在喷漆后要进行的工作就是烤漆,烤漆时如果稍不注意,灰尘就会使漆面污染,这样前期工作就白做了。那要如何在济南快速钣金喷漆时避免漆面污染呢?

Our car as a means of transport, we all like to dress up and go out, so there are times the face. Auto parts spray can meet your requirements, as long as you want to, spray paint manufacturers will be able to do for you. After the painting work is paint, paint if a little attention, the dust will enable paint pollution, this preparatory work for white. How then to avoid surface pollution in Ji'nan fast sheet metal paint when?

专业的烤漆厂家都会在烤漆房内进行,这样喷涂受污染的几率比较低。我们可以从以下几个方面,避免污染:

Professional paint manufacturers will in the baking room, so spraying contaminated low probability. We can avoid pollution from the following aspects:

1.通风扇能将外面的空气从顶棚灌入烤漆房内,向下带着灰尘,从底部排出去。由于形成的是低压气体,不会将灰尘吹起来。外面要经常检查通风扇是不是被堵塞了,能不能正常工作。

1 fan can be poured into the outside air from the ceiling paint room, down with the dust, discharged from the bottom. Since the formation of the low pressure gas, will not be blown up dust. Outside to regularly check the fan is not blocked, can not work properly.

2.顶部的过滤棉、底部的吸附棉和风机棉,能过滤掉大量的灰尘,保证烤漆房内的环境无污染。应及时更换,保持清洁。

2. At the top of the filter cotton, the bottom of the adsorption of cotton and fan cotton, can filter out a lot of dust, ensure paint room, no environmental pollution. Should be replaced in time to keep clean.

3.济南快速钣金喷漆 http://www.polo-king.cn/ 房内不能堆放杂物,这些东西久了会产生污染物,污染烤漆房内的空气环境。都应单独存放起来,放在通风口或者储藏室内

3. Jinan fast sheet metal spray paint room not piling up debris, these things for a long time will generate pollutants, pollution paint room air environment. It should be stored separately, a vent or storage room

4.用一次性的产品来遮盖汽车,像棉质产品会产生棉絮、灰尘等,容易附着在烤漆表面

4 the use of disposable products to cover cars, like cotton, cotton and other products will produce dust, easily attached to the paint surface

5.在烤漆、喷涂以前,一定要把汽车的每个角角落落都侧地清洗一遍。因为汽车本身就是一个油渍很多的东西,如果前期不清洗干净,后期很难喷涂。就是喷涂上了,效果也会很差,容易脱落。

5 in the paint, spraying before, must take each corner car and corner side to clean it again. Because the car itself is a fat lot of things, if not pre cleaned, the latter is difficult to spray. Is sprayed on the effect will be very poor, easy to fall off.

6.只有喷涂工作能在烤漆房中进行,像清洗、油漆配色等准备工作都要在外面先完成。

Only 6 of the work to be carried in the paint spraying room, like cleaning, paint color and other preparatory work must first complete the outside.

7.济南快速钣金喷漆工作人员一定要穿专门的工作服,带橡皮手套、面罩和呼吸器。很多喷涂厂从修理、打蜡、抛光、喷涂等一系列工作都是一个人完成,在这个过程中都是穿一件工作服,这是不对的。因为衣服上有很多细菌、纤维、油渍、汗液,会滴落在喷涂表面上。所以没有专业工作服的员工是不能进入烤漆房的,以免造成污染。

7 Ji'nan quick sheet metal spray paint staff must wear special work clothes, wear rubber gloves, masks and breathing apparatus. A lot of spraying plants from repair, waxing, polishing, spraying a series of work is a person, in this process is to wear clothes a piece of work, it is not right. Because there are a lot of bacteria, fiber, oil stains, sweat clothes, falls on the spraying on the surface. So there is no professional work staff can not enter the paint room, so as not to cause pollution.

8.每次喷涂完了以后,都要对喷枪、机器、地板、墙面、遮盖物等进行清洗。以免油漆块、灰尘等在喷涂使,喷到漆面上。

8 after each spray, spray gun, machine, floor, wall, cover, etc.. In order to avoid dust, paint spraying in the block, to spray paint on.

一键拨号一键导航